Pest Control: Clean, Documented, Audit-ready
Pest control at Solar Farm Thailand protects plant health and product quality without chemical pesticides. The approach fits GACP and supports medical cannabis buyers in Thailand. Traps, monitoring, and records work together so a cannabis farm Bangkok delivers consistent output for cannabis wholesale in Thailand.
Non-chemical methods come first under GACP. Solar Farm Thailand plans placement, counts activity, and documents actions on a fixed schedule. Rooms follow the same pattern so results are comparable over time. Records are complete, readable, and ready for review.
Sticky traps: placement and review
Yellow sticky traps monitor mother and veg rooms with mapped placement to avoid blind spots. Each trap is dated and tagged; staff replace weekly, log counts in the cloud, and trigger targeted action with a follow-up when thresholds are crossed.
Insect light traps: operation and upkeep
Light traps guard entries and busy corridors during light-on periods. Replace glue boards monthly or when loaded, quick-check lamps each round, and log on unit cards. Consistent service keeps capture rates steady.
Records, traceability, and action
Every action lands in the cloud. Sticky trap counts, light trap maintenance, and room notes carry timestamps, names, and locations. Supervisors scan exceptions daily and assign corrective work when needed. Photos attached for clarity. Audit trails show what was found, what was done, and whether it worked. Buyers and inspectors see the same source data the team uses to run the farm.
Reading the counts, not just recording them
A weekly trap count is only useful when it carries an identification. Fungus gnats usually point to wet substrate, thrips tend to arrive on cuttings, whitefly often follows a gap in room sealing. Logging the species beside the number lets the action match the cause, not the symptom.
One threshold for every room hides the difference between a long-lived mother room and a fast-turning veg room, so typical practice is to set thresholds per room type and read the trend across weeks, not any single count.
The commonest false reading is a saturated trap or one past its change date: low capture then reads as low pressure. The date on the trap must agree with the log entry for that position, usually the first cross-check an auditor makes.
Closing an exception properly
An assigned exception is not a resolved one. The record needs the finding, location, action, the person who took it and a follow-up count showing pressure fell; otherwise the log shows activity, not effectiveness.
Corrective actions that fit a non-chemical GACP programme are mostly cultural: removing affected leaves or plants, correcting irrigation and drainage, sealing a door or duct gap, tightening the trap grid in that zone. If the follow-up count does not fall, the action is repeated or escalated, never closed on a promise.
The independent third-party Certificate of Analysis on every batch covers pesticide screening, so the chemical-pesticide-free approach at Solar Farm Thailand is verified at the product end as well as in the log.
What an auditor or licensed buyer actually asks for
A typical review walks the trap map against the floor, pulls one trap and asks for its log entry, then picks one exception and follows it to closure.
- Trap map matches positions in every room; no untagged or undated traps
- Replacement dates on traps and glue boards agree with the cloud log
- Each exception has a named owner, a dated action and a verification count
Predictable failures: two systems of record that disagree, gaps around staff changes, thresholds never reviewed. In Khlong Luang, Pathum Thani, north of Bangkok, insect pressure runs all year, so the cadence is fixed, not seasonal.
Outcome
Pest pressure stays low. Flowers stay clean. Audits move quickly because controls are simple, repeatable, and well documented. Solar Farm Thailand supplies medical cannabis that meets specification and arrives on schedule for cannabis wholesale Bangkok and nationwide partners.
FAQ
Sticky traps, insect light traps, mapped placement, and cloud logs verify control.
Sticky traps weekly; glue boards monthly or sooner if loaded.
Last updated: 15 September 2026